PA State Auto Inspection Exam Questions with Answers Latest Update 2024, Exams of Nursing

Download PA State Auto Inspection Exam Questions with Answers Latest Update 2024 and more Exams Nursing in PDF only on Docsity! PA State Auto Inspection Exam Questions with Answers Latest Update 2024 Stickers shall be kept where? - Correct answer Kept under lock and key in a safe place What is done with any unused stickers? - Correct answer Keep them until the QAO comes around. You get a 75% refund on unused stickers. First offense of faulty inspection and improper inspection? - Correct answer Category 1 violation. 2 months suspension. When checking registration or VIN what do we look for, and what if there's a problem? - Correct answer VIN number and license plate must agree with registration card. Allowed to have one number off or two numbers transposed (out of order) if the owner proves forms have been sent to Penn DOT. VIN plate can't be loose, defaced, or missing. If there is a problem owner must get a corrected registration or show that proper forms have been sent to Penn DOT. What do you check glazing for? - Correct answer Approved safety glass must be in every window and it must be permanently labeled. See Appendix C(f) Non transparent material or glass etchings may not obstructs the drivers view and may not be higher than 3-1/2 inches from the bottom of any side or rear window. Glass may not be shattered, broken or have sharp edges. No defects in the acute area or the critical area or the windshield. Louvers can't obstruct driver's vision. Dual side mirrors are required when using sunscreen or louvers. What area of the windshield can there be no imperfections? - Correct answer The acute area. (8-1/2 X 5-1/2) List all the ways to check the wipers. - Correct answer Speed at manufactures specs or at least 45 cycles per minute Blades can't be torn or smear or streak after 5 cycles. Must have all wipers Wipers must reset to rest position. Washer system working on cars/light trucks newer than 1968. What do you check the doors and trunk lid for? - Correct answer Must be original equipment or same type. Must close securely. List all the ways to check mirrors. - Correct answer Mirrors can't be cracked, discolored or broken., Mirrors must hold adjustment. Can't be loose. Cars with louvers and sunscreens must have 2 outside mirrors (19-1/2 square inches each). No junk hanging from rear view mirror. What's the rule for fender flares? - Correct answer May not exceed 3 inches. What do you check floor for? - Correct answer Must be able to support weight of people and cargo. No holes allowed. What is the bumper height for a car and a truck. - Correct answer Must be as strong as and no longer than original bumper. Can't be broken or torn. Wood planks on service trucks (wreckers) only. Height- passenger vehicles 16-20 inches above ground MPVs, SUV's and light trucks 16-30 inches above ground. Turn signals should have a frequency of flash between __________ flashes per minute. - Correct answer 60 - 120 flashes per minute. What are the guidelines for back up lights? - Correct answer Must turn off when not in reverse OR have a dash indicator light or audible warning. What are the guidelines for broken lenses? - Correct answer Will not pass if white light shows through. List three reasons for rejecting shocks. - Correct answer Missing shocks Mounts or mounting bolts broken Severe leakage. Slight dampness OK What's the minimum steering wheel size? - Correct answer 13 inches The horn should be heard at least ________feet away. - Correct answer 200 feet What do we look for when checking the brake pedal? - Correct answer Can't go down more than 80% of total travel. Can't fade when vehicle is stopped. (bleed by in master cylinder) No excessive friction in linkage. What is the most an unmarked drum can be machined? - Correct answer .090" over original diameter. What is the deepest a groove can be in a drum or rotor? - Correct answer .015" . Can a ply be broken on a leaf spring? - Correct answer Yes. MAIN leaf may not be broken. What do we check inside the trunk for? - Correct answer No holes in floor bed or inner panels Floor strong enough to hold cargo. How do we check the emergency brake? - Correct answer Brakes must set before pedal travels it's limit. Brakes must exhibit resistance when you try to move the car. Acute area - Correct answer The part of the windshield 8-1/2 inches wide by 5-1/2 inches high directly in front of the driver's line of vision. Critical area - Correct answer The part of the windshield that the wipers sweep. Fleet inspection station - Correct answer A station certificate to inspect all types of vehicles leased or owned by the person that has the station certificate. Must have at least 15 vehicles. GVWR - Correct answer The loaded weight of a single vehicle as specified on the Federal weight certification label attached to the vehicle. ( DIFFERENT THAN (GW) GROSS WEIGHT ) Light truck - Correct answer Registered gross weight of 11,000 lbs or less. Medium truck . - Correct answer Registered gross weight from 11,001 to 17,000 lbs inclusive Heavy truck - Correct answer Registered gross weight in excess of 17,000 lbs. Safety insert tab - Correct answer The numbers applied to the inspection sticker (safety certificate of inspection) that show when the sticker expires. Passenger vehicle - Correct answer Motor vehicle (except a motor cycle) designed to carry 15 passengers or less. Primarily used for transporting people. A bus is a vehicle designed to carry 16 or more passengers (including the driver) Certificate of inspection - Correct answer Inspection sticker MV 431 - Correct answer Use MV-480 for motorcycles, mopeds, and trailers. Inspection report sheet for all motor vehicles EXCEPT motor cycles and motor driven cycles. (mopeds 5 H.P. or less) Annually - Correct answer Once a year (12 months) Semi annually - Correct answer Twice a year (6 months) What must you or the station owner do when you start at a new place? of employment? - Correct answer Notification must be given to the quality assurance officer and the Vehicle Control Division. Your name must be placed on Form TS-443 (listing of mechanics) Stipulation for fog lamps. - Correct answer May be used only with low beam headlights. Stipulation for driving lamps - Correct answer May be used only with high beam headlights. Foreign vehicle - Correct answer Any vehicle not registered in Pennsylvania. How can we tell if a vehicle is from an emission inspection area? - Correct answer Look for the emissions insert on the inspection sticker or a emissions inspection sticker. Look for the IM on the registration card. If a vehicle is from an emission area, what is our responsibility when inspecting the vehicle? - Correct answer When placing the inspection sticker on the vehicle we must use an emissions insert. . Name the 3 types of vehicles we check "scrub" line on. - Correct answer Street Rods Specially Constructed Vehicles Reconstructed Vehicles. List the types of hammers required for the inspection station. - Correct answer Ball- peen Plastic or Brass Rubber An inspection station must be open for a minimum of ______ hours. - Correct answer 40 hours per day unless you get a waiver from the Bureau. If an inspection station is open on Saturday for fuel and service only must an inspection mechanic be on duty? - Correct answer NO- only during normal business hours (7:00 - 5:00 Mon-Fri) Is the inspection fee for a vehicle that fails the same as for a vehicle that passes? - Correct answer Yes- Pass or Fail: Same price. Is the price of the sticker included in the fee for inspection? - Correct answer NO- the price of the sticker is separate. Must have a sign listing them separately. How many stations can a technician be registered at? - Correct answer As many as he/she wants to as long as they notify the inspection supervisor and the Vehicle Control Division of the Names and station numbers of the places they are working. What is the minimum age of the inspection mechanic? - Correct answer 18 What two documents must a mechanic carry when performing an inspection? - Correct answer Driver's License and Mechanic Card Must the inspection technician be re certified and if so how often? - Correct answer Yes - Every 3 years. How many days does a mechanic have to take his recertification test? after being notified it's due to expire? - Correct answer 180 days. What is the meaning of 20-20-12? - Correct answer A passenger vehicle going 20 MPH must stop within 20 feet without swerving outside of a 12 foot wide lane. To inspect a motorcycle does the inspection mechanic need a motor cycle license? - Correct answer YES . What 5 items must be marked on the back of the certificates of inspection? - Correct answer (stickers) Expiration date, VIN, Date of inspection, Brakes inspected, Signature Is a new Certificate of Appointment needed if you move your business to a different building? - Correct answer YES - and you may not do any inspections until then. What must be done if certificates of inspection are stolen? - Correct answer You must report it at once to the quality assurance officer.